engine

  1. N

    NCV3: 2006-2018 anyone interested in an engine to rebuild?

    Diesel V6 OM-642 engine for rebuild in OR (PDX) Hi!, I have a 2010 2500 Sprinter engine (V6, 3L) with 160,000 miles on it that runs, but has a knock. Mechanic thinks it needs a new crankshaft...engine was run without oil in it (a leak situation). I have obtained a new engine for my vehicle...
  2. R

    Nozzle spraying fuel all over [OM612] engine... any clues?!

    Hello folks... there's a little connection right at the front of my engine spraying fuel all over the place... any ideas if this is something i can DIY... (without too much skills.) or do i need a pro?! thanks https://ibb.co/mh2Zb8W
  3. L

    Punked! (What would you do?)

    Hi Folks, I just bought a converted 2005 Dodge Sprinter 2500 from a guy in Jersey. A couple hundred miles into owning it, I started overheating. Pulled over immediately and saw that one of the coolant hoses had blown. I reattached it, refilled the coolant, and continued. I continued to lose...
  4. N

    OM647 swap into different vehicle.

    This is a rough idea at this point. Always thought of engine swapping something and these engines have really grown on me, and also it would be different then what most people would do. What I'm asking is I have pretty much a whole sprinter, runs and drives perfectly fine. Im wanting to swap the...
  5. G

    Engine Replacement

    Hello All, I own a 2004 Dodge Sprinter 2500 with 245,000 miles that needs a new engine. According to my mechanic a connecting rod broke while he was test driving it attempting to diagnose my LHM issue. He quoted me 12,000 to get it replaced with a used motor and that is well above my budget. I...
  6. D

    whistling turbo

    My 07 sprinter ( 08 View) developed a whistle starting at 1100 rpms and going to 2200 rpms where I cannot hear it any more, probably because of engine noise or high frequency pitch. I drove it 1500 miles home with the whistle after a Nevada diesel shop saw no big issues. The local Mercedes...
  7. K

    WTB NV3 engine, swap needed in Kennewick WA, mechanic needed too

    2012 lost a wrist pin due to poor maintenance by previous owner.
  8. C

    OM642 Engine

    Recently bought a 2011 sprinter w/a seized engine. Looking for something affordable. Located in Chicago/NW Indiana. Willing to travel to pick up. Any leads would be helpful too! Thanks, Danny
  9. M

    2002 Freightliner Sprinter loss of power

    Hi guys I have an 02 sprinter that all of a sudden would not build boost. I can manually depress the turbo actuator and it will build boost then, so I know its not the turbo. I can also suck on the vacuum hose and make the actuator go down so I know its not the actuator. I replaced the vacuum...
  10. ecowhale

    EGR, DPF Sensors, Cleaning and Code Issues

    2007 Dodge Sprinter 3.0 Diesel with 165,000 miles. Current Persistent Code: P040D Exhaust Gas Recirculation (EGR) Temperature Sensor A Circuit High. Chronology of events that lead to current engine light and code P040D: The engine light came on, OBD reader said P0544 exhaust sensor 1. I...
  11. O

    Engine will start but not run. No luck with battery (Video)

    My engine won't run. I was working inside my 2006 Sprinter last night with the interior light on for no more than 30 minutes. Took it for a drive an hour or 2 before with no issues. The lights and dash all still come on when I turn the key. The engine even starts but won't turn over and run...
  12. A

    crank no start issue need help asap

    hi i have a shop we work on alot Sprinters we have this 2014 2.1L :bash:for one of my accounts it got towed in he picked up bad diesel so clogged the filter and fuel pump so i replaced the fuel pump assembly fuel filter blew out all the fuel lines primed the system with Fresh Diesel activated...
  13. A

    crank no start issue need help asap

    hi i have a shop we work on alot Sprinters we have this 2014 2.1L :bash:for one of my accounts it got towed in he picked up bad diesel so clogged the filter and fuel pump so i replaced the fuel pump assembly fuel filter blew out all the fuel lines primed the system with Fresh Diesel activated...
  14. P

    Rain Leaking Into Engine Compartment

    I recently purchased a 2008 Sprinter 2500 Cargo for a camper conversion. I noticed that rain water seems to be leaking into the engine compartment. Water ends up on the ECM and also pools farther below on the bracket below the windshield wiper fluid reservoir (see picture). In testing for the...
  15. D

    Purpose of the Engine Cover

    On another forum a person said that the MB dealer did not replace the engine cover after servicing his 2009 NCV3. He wondered if that was just an oversight, or if there was a good reason not to use it. That got me wondering the purpose of the Engine Cover. Perhaps it is to reduce the...
  16. B

    Sprintshift malfunction with engine running, OK on ignition.

    Yes, i got myself an 216CDI from 2001 with the sprintshift. The problem, with engine running it refuses to go into gear, stuck in N. But with only the ignition on and engine not running it shifts as its supposed to. Hydr.pump is new. What can be the problem here? And yes i've been searching...
  17. N

    Engine stalling or limp mode when starting

    My 2005 2500 has been in the shop now over 3 weeks attempting to fix a problem where almost every time I start the van it either starts and putters/shakes until it stalls out or seems fine until you try and accelerate and the tac wont go above 1000 RPMs and speed it limited to about 5 mph. The...
  18. A

    scan tool

    im looking for a new scan tool possibly a Mercedes one just for sprinter is anyone knows someone or anyone that wants to sell them lmk asap thanks :rad::smirk::shhh::professor::2cents::2cents::2cents:
  19. A

    converter issue

    hi i own a repair shop service a lot of sprinter i have a customer with a 2011 MB sprinter 2500 3.0L 339k miles on it Ive replaced all exhaust temp Nox o2 sensors everything and the converter from Mercedes Ive replaced the converter 6 times already and im at wits with this thing ive recoded...
  20. H

    Seized engine? 316CDI

    Hello guys, I'm sorry that my first post in theese forums is of this character. My small company located in Norway, Europe owns a 2011 316 CDI extra long (rwd) with automatic transmission (4+1?). We've had it since May 2014, and it has just passed 150 000 km. We've got cold winter conditions...

Top Bottom